The 1947 - Present Chevrolet & GMC Truck Message Board Network







Register or Log In To remove these advertisements.

Go Back   The 1947 - Present Chevrolet & GMC Truck Message Board Network > 47 - Current classic GM Trucks > The 1967 - 1972 Chevrolet & GMC Pickups Message Board

Web 67-72chevytrucks.com


Reply
 
Thread Tools Display Modes
Old 07-11-2018, 07:21 PM   #26
dmjlambert
Senior Member
 
dmjlambert's Avatar
 
Join Date: Apr 2016
Location: Cypress, TX
Posts: 1,130
Re: My kingdom! My kingdom! My kingdom for an HEI module that will last

Generally speaking, HEI was not put into cars and trucks by GM until the alternators went to internally regulated. And the distributor power wire was not routed to the starter any more to provide the full 12V during start, because HEI distributors were not powered by a resistor wire.

Since you can't know for sure what caused your module to fail, all you can do is improve the conditions it runs with, to make them more favorable or modern. So, that means upgrading to a 12SI or CS130 alternator and remove the external regulator, making sure the distributor power wire is not tied to the starter solenoid like it was from the factory, and replacing the old coil with a good one, perhaps an ACDELCO one from Rock Auto or have a local store like O'Reilly order one if all they want to give you immediately across the counter is their store brand. Other general tune up things like replacing the spark plug wires and distributor cap, if it has been a long or unknown time for that, would also be a good idea.
dmjlambert is offline   Reply With Quote
Old 07-11-2018, 09:52 PM   #27
ZEKE68
Senior Member
 
ZEKE68's Avatar
 
Join Date: Jul 2012
Location: Space Coast, Florida
Posts: 372
Re: My kingdom! My kingdom! My kingdom for an HEI module that will last

I had an 1981 C10 which had a six with the HEI in it for five years, then I put in a Target Master 350 which I ran an HEI in for another ten years, and I never had a module go bad. Never knew it was an issue. I have run a HEI in my 68 C10 for the last six years with an internal regulated alternator and have not had a problem with it either.
__________________
1968 SWB Step Side, Big Block, 4L80E , Running!
ZEKE68 is offline   Reply With Quote
Old 07-11-2018, 10:39 PM   #28
BRL
Registered User
 
BRL's Avatar
 
Join Date: Jun 2014
Location: Washington
Posts: 209
Re: My kingdom! My kingdom! My kingdom for an HEI module that will last

...yep...brings back good ol' memeories..I do remember...so like this one time at band camp......

So like this one time...I nailed down an Accell Hi Power module from O'Reliey's...without the silicone base grease insulator ,and I over torqued the base screws until...I heard a SNAP!

2 months later, it just died in the middle of nowhere!

Fortunately, I had the foresight to carry a 4 pin spare...

They are nice to have along!

Carry a spare!

BRL is offline   Reply With Quote
Reply

Bookmarks

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT -4. The time now is 08:35 PM.


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2018, vBulletin Solutions Inc.
Copyright 1997-2013 67-72chevytrucks.com