The 1947 - Present Chevrolet & GMC Truck Message Board Network







Register or Log In To remove these advertisements.

Go Back   The 1947 - Present Chevrolet & GMC Truck Message Board Network > 47 - Current classic GM Trucks > The 99-06 GMT800 Chevy and GMC Message Board

Web 67-72chevytrucks.com


Reply
 
Thread Tools Display Modes
Old 05-05-2018, 02:33 PM   #1
bennylava
Registered User
 
bennylava's Avatar
 
Join Date: Jul 2017
Location: Texas
Posts: 396
Looking to buy 02... a few questions

Looking to buy an 02 Chevrolet truck. So here's a few questions.

1. I want the extended cab... maybe the 4 door? I'm afraid I'm not sure what the difference is. Was there an extended cab 2 door?

2.Also, I'm not sure if I'm looking for an 02, or an 03. What was the last year of the horizontal headlights? I'm not a huge fan of the slanted eyes look. But I can't remember if the last year of of the headlights I want was 02, or 03.

3. Is there anything in particular that I should watch out for when buying one? Factory defects, commonly known flaws, etc.

4. What were all the colors available? I think I've seen red, white, black, and tan. This would be chevy colors only, as I'm not looking to buy a GMC truck.

5. What was the highest options package? Want to make sure I get that.

6. Was there much of a difference in the engines? All I know is that the 5.3L was available. Did they have the 6.0L back then, or was it something else? And when it comes to modding it a gas mileage, what would be the differences in the engines? I'd like to give it a power bump but I don't want to get 10mpg.

Thanks in advance! I'm sure I'll pop back in here with more questions.
bennylava is offline   Reply With Quote
Old 05-05-2018, 08:05 PM   #2
95 S_Trucker
Registered User
 
95 S_Trucker's Avatar
 
Join Date: Oct 2009
Location: .
Posts: 2,178
Re: Looking to buy 02... a few questions

#1. The standard ext cab had 3 doors. There was an option for the fourth door.

#2. 03 was the first year for angry eyes.

#3. Brake lines and fuel lines rust out in areas where road salt is used. Nothing else out of the ordinary.

#5. Lt was the highest trim level on a Chevy.

#6. 5.3 was the biggest motor you could get in a Chevy 1500. The gmc c3/Denali had the 6.0.
95 S_Trucker is offline   Reply With Quote
Old 05-09-2018, 10:10 PM   #3
bennylava
Registered User
 
bennylava's Avatar
 
Join Date: Jul 2017
Location: Texas
Posts: 396
Re: Looking to buy 02... a few questions

Thanks! Anyone have the quick and dirty on power mods for the 5.3L, that won't hurt mpg? Exhaust obviously, maybe some kind of mild cam? Even something like better rocker arms? A tune? What's everything I can do that would boost power but not hurt MPG?
bennylava is offline   Reply With Quote
Old 05-09-2018, 11:29 PM   #4
Killer Bee
Registered User
 
Killer Bee's Avatar
 
Join Date: Jan 2016
Location: Barber City, CA
Posts: 4,717
Re: Looking to buy 02... a few questions

early 5.3l heads had thin castings in areas proned to cracking.. my '02 was drinking a gallon a week through both heads..

due to family hookup, cheaper to repower.. made the swap around 145k miles 12 yo..

knock sensors were a pita but knocked them out in the driveway on a Sunday afternoon..

oil pressure sender went geyser on me, year after having intake off, if only I had known

plastic heater hose connection blew a mile from work, easy fix but depends where/when it goes..

water pump, trans job, one tune up, couple of batteries and sets of tires, that's about it.. original brakes made it almost 140k miles!

I'll admit though, I work it hard and it doesn't even know it's only a half ton

if I had known what I would eventually use it for, would have bought a bigger truck..

but I don't regret it, been a great truck for all the heavy jobs and 185k miles and plenty more in it..

having smog checks in CA I've only installed k&n kit and single flow master, plenty of power for chores and looks good doing them

good luck!

















__________________
I started out with nothing - and I still have most of it
Killer Bee is offline   Reply With Quote
Old 05-10-2018, 11:08 AM   #5
truckdude239
Senior Member
 
truckdude239's Avatar
 
Join Date: Sep 2005
Location: Lewisville, Nc
Posts: 10,216
Re: Looking to buy 02... a few questions

instrument clusters, knock sensor, intake gaskets, rear main seals leak, sometime the pump in the transfer case rubs though the case housing, other then that not much, i have a 2002 burb with 225k ive had 4 years i only done the intake gaskets knock sensors, vavle cover, and valley pan gasket, water pump, i just rebuilt the front end on it with all new ball joints upper control arms gear box inner and outter tie rods, pit and idler arm and schocks all the way around what a differance it made

now i was given in january a 2000 thaoe with 5.3 had 369k miles on it with orginal motor and trans it was leaking like crazy from everywhere and trans was shot idid a motor and trans swap with 150k used units and now it purring again
__________________
David fuller
Ase Certified Mechanic
Click here to help support our board!!


1971 Chevy c-10 under going a 4.8l LSx swap

Build Thread http://67-72chevytrucks.com/vboard/s...d.php?t=421305

2007 Honda Accord my daily 145kmiles
2002 Honda Accord 4 door With 330k(sisters car)
2005 toyota Avalon 228k( brothers car)
2002 Sububran 5.3 245k
2000 Tahoe 5.3l 378

General manager for Marco's Carwash & lube
truckdude239 is offline   Reply With Quote
Old 05-10-2018, 11:13 AM   #6
95 S_Trucker
Registered User
 
95 S_Trucker's Avatar
 
Join Date: Oct 2009
Location: .
Posts: 2,178
Re: Looking to buy 02... a few questions

Instrument clustars are only common on the 03+ trucks. Not so much the 99-02.

The rest of the stuff isn't common, just some peoples experiences.
95 S_Trucker is offline   Reply With Quote
Old 05-11-2018, 07:40 AM   #7
mountie
Registered User
 
mountie's Avatar
 
Join Date: Jun 2011
Location: Bradenton, Fla.
Posts: 1,100
Re: Looking to buy 02... a few questions

If by chance you are looking for a truck, I found this MINT, 2000 SLT w/ an ARE topper painted to match. One owner ( retired) & garaged. I REALLY considered this, when I was deciding on my (just bought), 2005 Yukon XL , SLT.

Sarasota, Fl. truck.... I could call him if he still wants to sell it ($6,600?) .. I think it has only 98,000 or 110,000 miles.... ( somewhere around that)
Attached Images
 
__________________
'70 GTO Midnight Blue
'88 GMC Sierra SLE 392,000 miles-(2018) sold to Classic car shop in Germany.
'93 Cadillac STS Black
'93 Mercedes SL 500 Teal
'86 Yamaha FZ750 - 15,000 RPM
'86 Yamaha FJ1200 - Criminally Fast
2016 Ferrari 488 GTB, I drive it - don't own it.
'05 GMC Yukon XL , SLT 4wd ( just purchased 2018)

Last edited by mountie; 05-12-2018 at 12:05 PM.
mountie is offline   Reply With Quote
Old 05-12-2018, 11:15 AM   #8
bennylava
Registered User
 
bennylava's Avatar
 
Join Date: Jul 2017
Location: Texas
Posts: 396
Re: Looking to buy 02... a few questions

I wonder what the difference between the LT, and the SLT was. Does anyone know the differences between all the various packages?
bennylava is offline   Reply With Quote
Old 05-12-2018, 12:01 PM   #9
mountie
Registered User
 
mountie's Avatar
 
Join Date: Jun 2011
Location: Bradenton, Fla.
Posts: 1,100
Re: Looking to buy 02... a few questions

Quote:
Originally Posted by bennylava View Post
I wonder what the difference between the LT, and the SLT was. Does anyone know the differences between all the various packages?
SLT has more, or all of the luxury options. ( My Yukon XL SLT is 98% Denali widgets)
__________________
'70 GTO Midnight Blue
'88 GMC Sierra SLE 392,000 miles-(2018) sold to Classic car shop in Germany.
'93 Cadillac STS Black
'93 Mercedes SL 500 Teal
'86 Yamaha FZ750 - 15,000 RPM
'86 Yamaha FJ1200 - Criminally Fast
2016 Ferrari 488 GTB, I drive it - don't own it.
'05 GMC Yukon XL , SLT 4wd ( just purchased 2018)
mountie is offline   Reply With Quote
Old 05-12-2018, 12:32 PM   #10
95 S_Trucker
Registered User
 
95 S_Trucker's Avatar
 
Join Date: Oct 2009
Location: .
Posts: 2,178
Re: Looking to buy 02... a few questions

Quote:
Originally Posted by bennylava View Post
I wonder what the difference between the LT, and the SLT was. Does anyone know the differences between all the various packages?
LT is Chevy and SLT is GMC.
95 S_Trucker is offline   Reply With Quote
Old 05-12-2018, 12:40 PM   #11
mountie
Registered User
 
mountie's Avatar
 
Join Date: Jun 2011
Location: Bradenton, Fla.
Posts: 1,100
Re: Looking to buy 02... a few questions

I stand corrected.... ( hard to keep up with those letters)...
__________________
'70 GTO Midnight Blue
'88 GMC Sierra SLE 392,000 miles-(2018) sold to Classic car shop in Germany.
'93 Cadillac STS Black
'93 Mercedes SL 500 Teal
'86 Yamaha FZ750 - 15,000 RPM
'86 Yamaha FJ1200 - Criminally Fast
2016 Ferrari 488 GTB, I drive it - don't own it.
'05 GMC Yukon XL , SLT 4wd ( just purchased 2018)
mountie is offline   Reply With Quote
Old 05-12-2018, 01:51 PM   #12
68Gold/white
Registered User
 
Join Date: Sep 2011
Location: Ark City, Kansas
Posts: 3,263
Re: Looking to buy 02... a few questions

Killer Bee,
So you replaced your 706 heads? What heads did you use for replacements???
Thanks.
68Gold/white is offline   Reply With Quote
Old 05-12-2018, 07:29 PM   #13
Killer Bee
Registered User
 
Killer Bee's Avatar
 
Join Date: Jan 2016
Location: Barber City, CA
Posts: 4,717
Re: Looking to buy 02... a few questions

^ repowered with complete long block, not sure p/n but was a stock GM reman with national warranty..

new heads are 862 which I believe are very similar to 706

this was a widely known issue, google this TSB, there's chat on lots of forums about it..

#06-06-01-019B

I was guesstimating my timeline above, engine swap was July 2015 157k miles..

probably drinking coolant since 2013 or so.. water pump was replaced in 2014 for very minor leak while at my buddy's garage for other work..

I was 99% sure the tiny little dribble not reaching the ground wasn't the cause of the volume of coolant it was losing..

but had him replace the water pump anyway with high hopes it wasn't the heads..

less than a month later the factory new GM water pump was leaking, tube fitting to cast b/o, ended up replacing that one myself

year later it was up to a gallon a week or more.. at the end, stopped three times to refill expansion tank getting it to Henderson for repower..


problem with being a professional mechanic for a company where you can't work on your own vehicles..

often have to rely on other garages and friends to handle jobs you don't have time for in your driveway..

timing always seems to be lousy for breakdowns.. knock sensors, fuel pump etc. I did because they went b/o when I had time..

good luck!
__________________
I started out with nothing - and I still have most of it
Killer Bee is offline   Reply With Quote
Old 05-13-2018, 11:22 AM   #14
bennylava
Registered User
 
bennylava's Avatar
 
Join Date: Jul 2017
Location: Texas
Posts: 396
Re: Looking to buy 02... a few questions

What were the best heads for the 5.3L?

Are the stock heads worth fixing up? Or would it be better to go with some aftermarket set? (again not too aggressive so as to not harm MPG much)
bennylava is offline   Reply With Quote
Old 05-23-2018, 04:01 AM   #15
bennylava
Registered User
 
bennylava's Avatar
 
Join Date: Jul 2017
Location: Texas
Posts: 396
Re: Looking to buy 02... a few questions

Also how do you identify an LT truck? I don't remember seeing LT badges on the side of any of these trucks.
bennylava is offline   Reply With Quote
Old 05-23-2018, 01:55 PM   #16
95 S_Trucker
Registered User
 
95 S_Trucker's Avatar
 
Join Date: Oct 2009
Location: .
Posts: 2,178
Re: Looking to buy 02... a few questions

There are badges at the bottom of the C pillar(B pillar if its a regular cab).
95 S_Trucker is offline   Reply With Quote
Old 05-30-2018, 04:36 AM   #17
bennylava
Registered User
 
bennylava's Avatar
 
Join Date: Jul 2017
Location: Texas
Posts: 396
Re: Looking to buy 02... a few questions

Quote:
Originally Posted by 95 S_Trucker View Post
There are badges at the bottom of the C pillar(B pillar if its a regular cab).
Thanks! I'll look there to make sure its the right trim level. Anyone happen to know what the real differences were between the LT and the other trim levels? Better sound system, automatic windows, stuff like that?
bennylava is offline   Reply With Quote
Old 05-30-2018, 07:24 AM   #18
mountie
Registered User
 
mountie's Avatar
 
Join Date: Jun 2011
Location: Bradenton, Fla.
Posts: 1,100
Re: Looking to buy 02... a few questions

Quote:
Originally Posted by bennylava View Post
Thanks! I'll look there to make sure its the right trim level. Anyone happen to know what the real differences were between the LT and the other trim levels? Better sound system, automatic windows, stuff like that?
Yes... stuff like that. ( Buying used, you are beholden to what options the original buyer requested)

I could assume, you see if the seats are power, then there will be more options.
__________________
'70 GTO Midnight Blue
'88 GMC Sierra SLE 392,000 miles-(2018) sold to Classic car shop in Germany.
'93 Cadillac STS Black
'93 Mercedes SL 500 Teal
'86 Yamaha FZ750 - 15,000 RPM
'86 Yamaha FJ1200 - Criminally Fast
2016 Ferrari 488 GTB, I drive it - don't own it.
'05 GMC Yukon XL , SLT 4wd ( just purchased 2018)
mountie is offline   Reply With Quote
Old 05-30-2018, 03:33 PM   #19
bennylava
Registered User
 
bennylava's Avatar
 
Join Date: Jul 2017
Location: Texas
Posts: 396
Re: Looking to buy 02... a few questions

I was hoping the LT was just a package that you either bought, or you didn't, and it came with a set number of options. But some cars are that way and some aren't.
bennylava is offline   Reply With Quote
Old 05-30-2018, 03:48 PM   #20
Killer Bee
Registered User
 
Killer Bee's Avatar
 
Join Date: Jan 2016
Location: Barber City, CA
Posts: 4,717
Re: Looking to buy 02... a few questions

not sure but I believe the Chevy and GMC option packages are slightly different..

my GMC SLE has most of what was available but leather, including left and right 6-way power buckets..

this may be a more accurate comparison;
https://www.gm-trucks.com/forums/top...t-differences/

if you're looking at actual ads that list options, soon you'll have a pretty good idea what was available..

good luck!
__________________
I started out with nothing - and I still have most of it
Killer Bee is offline   Reply With Quote
Old 05-30-2018, 04:11 PM   #21
mountie
Registered User
 
mountie's Avatar
 
Join Date: Jun 2011
Location: Bradenton, Fla.
Posts: 1,100
Re: Looking to buy 02... a few questions

The letters were a bit confusing to me too...
My Yukon is an SLT... leather, power buckets, seat memory, etc.
It has more standard options than an SLE.

Until I shopped, I thought the letters were the other way around.
__________________
'70 GTO Midnight Blue
'88 GMC Sierra SLE 392,000 miles-(2018) sold to Classic car shop in Germany.
'93 Cadillac STS Black
'93 Mercedes SL 500 Teal
'86 Yamaha FZ750 - 15,000 RPM
'86 Yamaha FJ1200 - Criminally Fast
2016 Ferrari 488 GTB, I drive it - don't own it.
'05 GMC Yukon XL , SLT 4wd ( just purchased 2018)
mountie is offline   Reply With Quote
Old 06-02-2018, 11:31 AM   #22
bennylava
Registered User
 
bennylava's Avatar
 
Join Date: Jul 2017
Location: Texas
Posts: 396
Re: Looking to buy 02... a few questions

Well a couple more questions have come up during my search.

1. How hard would it be to convert an 06 to the 02 front end? (i think they changed the bodystyle in 07). This is in case its too hard for me to find a nice 02 with reasonably low mileage.

2. Were there extended cab long beds and short beds? I don't think I want a crew cab. I'm looking for the extended cab where all 4 doors will open. But I'm not really interested in a long bed.
bennylava is offline   Reply With Quote
Old 06-07-2018, 07:44 PM   #23
NoStopN
Registered User
 
NoStopN's Avatar
 
Join Date: Jul 2016
Location: Murfreesboro, TN
Posts: 229
Re: Looking to buy 02... a few questions

1) You would need the '02 front fenders, bumper, hood, & all of the lenses (headlights & park lights). You could get lucky & find a donor '99-'02 or buy replacement parts & would pay more that way.

2) Funny thing, they had extended cabs with 5.5', 6.5', & 8' beds. The 8' beds are less plentiful & ext. cab/5.5' beds are the rarest. But those were just during the '03-'07 Classic body (angry eyes).
__________________
1969 GMC 2500. 250 I6, 4-speed w/ granny low
NoStopN is offline   Reply With Quote
Old 06-11-2018, 04:17 PM   #24
bennylava
Registered User
 
bennylava's Avatar
 
Join Date: Jul 2017
Location: Texas
Posts: 396
Re: Looking to buy 02... a few questions

Quote:
Originally Posted by NoStopN View Post
2) Funny thing, they had extended cabs with 5.5', 6.5', & 8' beds. The 8' beds are less plentiful & ext. cab/5.5' beds are the rarest. But those were just during the '03-'07 Classic body (angry eyes).
So for the 02, your options would just be the 5.5' and 6.5' beds? I'd probably better go with the 6.5' bed if I get an 02 then. 5.5' might be a little short.
bennylava is offline   Reply With Quote
Old 06-11-2018, 04:45 PM   #25
NoStopN
Registered User
 
NoStopN's Avatar
 
Join Date: Jul 2016
Location: Murfreesboro, TN
Posts: 229
Re: Looking to buy 02... a few questions

I might have confused you. In '02, you only had the 6.5' or 8' bed. The weird 5.5' bed didn't come out until '05.
__________________
1969 GMC 2500. 250 I6, 4-speed w/ granny low
NoStopN is offline   Reply With Quote
Reply

Bookmarks

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT -4. The time now is 07:23 AM.


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Copyright 1997-2022 67-72chevytrucks.com